Study of the Influence of Air Plasma Spraying Parameters on the Structure, Corrosion Resistance, and Tribological Characteristics of Fe–Al–Cr Intermetallic Coatings
Rakhadilov B. Bayatanova L. Kengesbekov A. Magazov N. Toleukhanova Z. Yeskermessov D.
July 2025Multidisciplinary Digital Publishing Institute (MDPI)
Coatings
2025#15Issue 7
The development of power engineering requires the introduction of new materials and technologies to improve the quality and durability of products. One promising direction is the creation of heat-protective coatings for the protection of working surfaces of turbine blades of gas turbine engines operating at temperatures up to 1000–1200 °C. Intermetallic coatings based on iron aluminides (Fe3Al, FeAl) have high resistance to oxidation due to the formation of an oxide layer: Al2O3. However, their application is limited by brittleness due to the so-called third element effect, which can be reduced through alloying with chromium. In this study the processes of formation of Fe–Al–Cr intermetallic coatings produced by air plasma spraying and the mechanisms affecting their stability at high temperatures were investigated. Experimental studies included the analysis of the microhardness, wear resistance, and corrosion resistance of coatings, as well as their phase composition and microstructure. The results showed that the optimization of sputtering parameters, especially in the FrCrAl (30_33) mode, promotes the formation of a coating with improved tribological and anticorrosion characteristics, which is associated with its dense and uniform structure. These data have an important practical significance for the creation of wear-resistant and corrosion-resistant coatings applicable in power engineering.
coatings , intermetallic , microhardness , plasma spraying , wear resistance
Text of the article Перейти на текст статьи
PlasmaScience LLP, Ust-Kamenogorsk, 070000, Kazakhstan
D. Serikbayev East Kazakhstan Technical University, Ust-Kamenogorsk, 070000, Kazakhstan
PlasmaScience LLP
D. Serikbayev East Kazakhstan Technical University
10 лет помогаем публиковать статьи Международный издатель
Книга Публикация научной статьи Волощук 2026 Book Publication of a scientific article 2026