A Study Of The Possibilities Of Using Linseed Flour And Rice Husk Fiber As An Additional Source Of Raw Materials In The Bakery Industry
Moldakulova Z. Bayisbayeva M. Iskakova G. Dikhanbayeva F. Izembayeva A. Sottnikova V.
2021Technology Center
Eastern-European Journal of Enterprise Technologies
2021#5Issue 11-11361 - 72 pp.
The paper is devoted to solving the problem of the nutritional and biological value of rye-wheat bread by enriching it with non-traditional local plants raw materials – linseed flour and rice husk fiber. Rice husks are rarely used in bakery production, and in most cases remain unprocessed. However, this research defined the right ways for using them and set as a preliminary work in this field. The study has been carried out in two stages: firstly, linseed flour was added to the rye-wheat bread recipe in an amount of 5; 10; 15; 20 % to the weight of wheat flour. Secondly, dietary fiber was added to these experimental samples, prepared from rice husks without removing amorphous silicon dioxide in an amount of 0.3; 0.5; 0.7 % to the total mass of rye-wheat flour. The optimization of the ratios of the flour components with a simplex-lattice design was carried out and the rheological measurements of dough and bread were conducted on the farinograph and Chopin alveograph. The study results experimentally found that mixtures of rye-wheat flour and linseed flour with the addition of fiber as “medium in strength” give bread with sufficient volume. The recipe optimization parameters indicated that rational percentage of fiber and linseed flour up to 0.5 % and 15 %, respectively allows increasing the nutritional and biological value of finished products, improves the crumb structure, gas-holding and water-holding capacity of bread, which in turn prevents the stale process and thereby increases the shelf life of finished products. The obtained results allow us to suggest that, this recipe optimization model could be used in further research, as studies in this direction are limited
linseed flour , recipe optimization , rheology , rice husk fiber , rye-wheat bread
Text of the article Перейти на текст статьи
Department of Technology of Bread Products and Processing Industries, Almaty Technological University, Tole bi str.,100, Almaty, 050012, Kazakhstan
Department of Food Technology, Almaty Technological University, Tole bi str.,100, Almaty, 050012, Kazakhstan
Department of Technology of Food Products, Mendel University in Brno, Zemedelska str.,1665/1, Brno, 61300, Czech Republic
Department of Technology of Bread Products and Processing Industries
Department of Food Technology
Department of Technology of Food Products
10 лет помогаем публиковать статьи Международный издатель
Книга Публикация научной статьи Волощук 2026 Book Publication of a scientific article 2026