Membranes Based on Cellulose and Copolymers of Acrylonitrile Prepared from Joint Solutions
Makarov I.S. Shambilova G.K. Vinogradov M.I. Anokhina T.S. Bukanova A.S. Kairliyeva F.B. Bukanova S.K. Levin I.S.
July 2023Multidisciplinary Digital Publishing Institute (MDPI)
Membranes
2023#13Issue 7
Cellulose and copolymers of acrylonitrile (PAN) are characterized by their chemical resistance to several conventional solvents. Therefore, these polymers are often used to obtain membranes for the recovery of such solvents. In this work, for the first time, composite membranes formed from highly concentrated mixed solutions based on cellulose and PAN are considered (the total content of polymers is 18 wt.%). For mixed solutions, the morphology and rheological behavior were evaluated. It is shown that the resulting solutions are two-phase, and their morphology depends on the components’ ratio and the system’s history. The non-monotonous change in the viscosity with the PAN content indicates a specific interaction of cellulose and PAN in N-methylmorpholine-N-oxide solutions. The rheological behavior of mixed solutions allows for their processing in conditions identical to those of cellulose solutions. The introduction of PAN into the cellulose matrix promotes a decrease in the structural order in the system, affecting the membranes’ transport properties. For composite membranes, it was found that with an increase in the content of the PAN phase, the retention of Remazol and Orange decreases, while the observed values are several times higher than those for cellulose membranes. The permeability of ethanol increases with increasing terpolymer content.
composite membranes , copolymers of acrylonitrile , morphology , N-methylmorpholine-N-oxide , nanofiltration , rheology , structure
Text of the article Перейти на текст статьи
A.V. Topchiev Institute of Petrochemical Synthesis, Russian Academy of Sciences, Leninsky Prospect, 29, Moscow, 119991, Russian Federation
Institute of Petrochemical Engineering and Ecology named after N.K. Nadirov, Atyrau Oil and Gas University named after S. Utebayev, Baimukhanov Street, 45A, Atyrau, 060027, Kazakhstan
Department of Chemistry and Chemical Technology, Kh. Dosmukhamedov Atyrau University, Studenchesky Ave., 1, Atyrau, 060011, Kazakhstan
A.V. Topchiev Institute of Petrochemical Synthesis
Institute of Petrochemical Engineering and Ecology named after N.K. Nadirov
Department of Chemistry and Chemical Technology
10 лет помогаем публиковать статьи Международный издатель
Книга Публикация научной статьи Волощук 2026 Book Publication of a scientific article 2026